September 2017
M T W T F S S
« Jul    
 123
45678910
11121314151617
18192021222324
252627282930  

Archives

Categories

VOA Site B, Greenville, NC

I took a brief vacation last week along the coast of North Carolina. It was relaxing and fun to be sure. I was also aware of and slightly curious about the Voice Of America shortwave site, a slight distance inland in Grimesland, NC.  Thus, I made arrangements visit the facility on my way home.  Chief Engineer, Macon Dail, was gracious enough to give us the guided tour.  The facility is an engineering marvel.  The scale and complexity is enormous.  The entire facility is scrupulously maintained.  Many of the transmitters and other equipment have been upgraded to make them more functional.   I tried to take meaningful pictures, but in many cases, they simply do not to justice.

Edward R Murrow Transmitting Facility, (VOA Greenville Site B) Grimesland, North Carolina

Officially known as the Edward R Murrow Transmitting Station of the International Broadcasting Bureau, VOA Site B was constructed in 1961.  Six of the eight shortwave transmitters are original to the construction of the building.  The other two (BBC SK55 and AEG S4005) were added in 1986.  All of the dipole curtain arrays, rhombics, transmission line and the antenna switching matrix are also original.  A few brief statistics about this site:

  • Land area is 2,715 acres (1099 hectare).
  • Over twenty six miles (forty two kilometers) of 300 ohm open transmission line rated at 500 KW.
  • Sixteen dipole curtain arrays, average antenna gain 17 dBi.
  • Twenty rhombic antennas, antenna gain 15 dBi.
  • Two of the dipole curtain arrays can slew azimuth and take off angle.
  • Three Continental Electronics 420A 500 KW Doherty modulated transmitters.
  • Three General Electric 4BT250A1 250 KW high level plate modulated transmitters.
  • One Brown Boveri Company (BBC) SK55C3 500 KW PSM transmitter.
  • One AEG Telefunken S4005 500 KW PDM transmitter.
  • Antenna switch matrix connects any of the eight transmitters to any of the thirty six antennas

While we were there, both of the newer transmitters were on the air, running at 250 KW.  The GE transmitters are used as needed and the Continentals are rarely used due to age, difficulty to tune, change frequencies and gross power inefficiency.

The station staff has, out of necessity, fabricated some very cool upgrades to the transmitters and facility.  The first of which is the alarm annunciator, which is based on a Star Trek (Original Series) sound scheme.  Once or twice I heard the bridge general alarm go off, followed by a female voice stating the problem: “GB8, OFF AIR.”

Chief Engineer’s office.  NCC-1701; no bloody A, no bloody B, no bloody C, and no bloody D

The GE 250 KW transmitters have been retrofitted with a computer controlled auto tune system for frequency changes.  The antenna switch matrix controller has been replaced by a PLC based system.  As the transmitters are so old, many of the transmitter specific parts need to be machined or fabricated locally.  The rest of the transmitter parts are stocked in a large parts storage room, all of which is meticulously labeled and tracked.  The floors are waxed and spotless, there is no dust on the horizontal surfaces, the work shop is clean, tools are put away, grass and weeds are cut, etc.  All of these little details did not go unnoticed and indicate great pride by the staff in the facility itself.

The heart of the facility is the control room which consists of four rows of equipment racks and a central operating position elevated above floor level.  Arranged around that are the eight shortwave transmitters in two long transmitter galleries.

VOA Site B control room

From this point, the operator can view all of the transmitters in the two transmitter galleries.

Operating position

Around the control operator are arranged a series of computer monitors showing various station function status.

Transmitter modulation and status indicators

Antenna Matrix status and control

VOA transmitter control and status (center)

Audio monitoring router

The equipment is installed into the equipment racks by type; one rack contains the frequency generators for each transmitter, the next contains first stage power amplifiers, the next contains audio processors and modulation monitors, etc.

Equipment racks and Shift Supervisor’s  office

Transmitter frequency generators

Audio processors, modulation monitors and patch panels

Backup audio feeds

The audio comes from the VOA studios in Washington DC via satellite. There are Comrex Access links as a backup and the Gentner EFT-1000s are used as a backup to the backup.  Prior to 1995, an eight hop microwave system covering the 300 mile (483 KM) distance was used.

GE 4BT250A transmitter with computer controlled tuning system installed

The station staff has created a computer controlled tuning system for the GE transmitters. Each transmitter can change frequency several times a day, during each frequency change, all of the transmitter stages need to be retuned. When done by hand, this can take several minutes to accomplish. The computer system uses follow pots and micro controllers to set the tuning elements to specific values. They can be touched up by hand if needed. A frequency change can usually be done in less than one minute.

GE 4BT250A transmitter

Your humble author and CE Macon Dail discussing the auto tune system

GE 4BT250A auto tune modification

GE 4BT250A IPA tube and input tuning.

The 2nd IPA and PA input tuning work the same way. The copper sleeve slides up and down over the coil to change resonant frequency. The vapor cooled tube sits inside the tub at the top, anode facing down. These tuning sections are a mechanical nightmare according to Macon. One of the reasons why VOA site A was closed down was due to the frequent frequency changes at that site causing excessive wear and tear on the old GE transmitters. This particular transmitter was being repaired; the staff was rebuilding a tuning network bypass capacitor assembly

GE 4BT250A transformer vault

The GE transmitter transformers still contain PCB’s. The plate transformers are in the back, basically pole transformers, one for each phase. Primary voltages is 4,180 volts, secondary rectified voltages are 12 KVDC (PA plate supply)  and 15 KVDC (modulator plate supply).

Hallway and maintenance access to back of GE transmitters

AEG Telefunken S4005 500 KW transmitter on the air

While we were there, the newer transmitters were in operation transmitting Spanish language programming to the Cuba on 13,605 KHz and 11,930 KHz.  Currently, the Greenville site is broadcasting mostly Spanish language programming with some English, French and Bambara language programming for Africa.

A fact that does not escape the notice of the staff.

VOA transmitter gallery, showing transmitters GB8 through GB4

Continental Electronics 420A 500 KW Shortwave transmitter control and metering panel

The three Continental 420A transmitters (GB-1, GB-2 and GB-3) are essentially a pair of 250 KW amplifiers combined. As these are Doherty power amplifiers, frequency changes are very difficult to effect. These transmitters spend most of their time in backup service.

Electrical distribution panel

The antenna matrix building is very impressive. Routing eight 250 or 500 KW transmitters to 36 different antennas takes a bit of doing. Mechanizing that set up is no mean feat. The pictures I took of the antenna matrix building do not show the size and complexity of the system.

Transmission line between transmitter building and antenna matrix building

For that, we need a satellite photo:

VOA Site B antenna matrix building

Basically, the transmitter building is in the lower left hand side of the picture. The transmission line go over to the antenna matrix building (looks like rectangular duct work), then run all the way to the back of the building. Each antenna transmission line come into the building and runs to the other side. Pneumatic arms then couple the transmitter line to the antenna line. This is all controlled by a custom made PLC and controlled by the operator from the main operating desk.

Custom made antenna matrix control system

300 ohm open transmission lines

300 ohm open transmission lines

Some of these lines are very long but have low loss due to the air dielectric. The most used antennas are the dipole curtain arrays.

Dipole curtain arrays

These consist of a series of broadband dipole antennas arranged side by side and stacked three or four high. behind those antennas is a reflector screen. There are two curtain arrays that are slewable. The dipole antennas phase relationship to each other can be changed to adjust the take off angle and azimuth, thus giving optimum coverage to the targeted area.

Close up curtain array

In this picture, the dipole antennas are to the right. Behind them is the reflector screen, behind that is the antenna feed system. Each antenna feed goes through the reflector screen to the center of the dipole antenna.

Each array requires four towers to support it.

Curtain dipole array supporting towers

Curtain dipole array supporting towers

Remote Antenna Switch.  Allows two antennas to use one transmission line.

The entire antenna field is viewable from an observation platform on the main building

Observation room

Entrance gate and slewable curtains in background

Curtain arrays

The entire facility is very impressive. The truth is, I could have spent several more hours there, but I know that people have jobs to do and I felt that I had taken up enough time. We often forget in this country that not everyone in the world has access to the internet. Shortwave broadcasting has a long reach and is not subject to government controlled firewalls or other forms of electronic censorship. Currently, the Greenville site is broadcasting mostly Spanish language programming with some English language programming for Africa. There are many areas in the world that are in political tension right now, some startlingly close to home. Places like Brazil, Argentina and Venezuela have been in the news lately. I do not see a time when these long reach broadcasting services will not be needed. Becoming a welcome source of good information for those affected people is good for brand USA. It would be money well spent to invest in a couple of new Continental 419H (still made in the USA) DRM capable transmitters for this facility. While the old GE and Continental units are great, the time may come when they are really needed but unavailable due to being down for repair.

Special thanks to Macon Dail for his time, knowledge and patience.

Those Shortwave Sites

How is our Alaska doing?

How is our Alaska doing?

It is a joke in circulating in Russia at the moment.  Kind of funny when you think about it.

In light of the developing situation in Eastern Europe, it may be wise to retain some of those HF broadcasting (AKA Shortwave) sites.  It may be too late for Canada, however, the US government still has a few high powered HF sites that they may want to hold onto for a while.  There are several ways that shortwave broadcasting can be beneficial.

  • Like all radio broadcasting, quality content is needed to attract listeners. Most of what is available on shortwave is religious or transparent government propaganda. There are exceptions to this, but they are rare. Introduce quality programming, and shortwave listenership will increase.
  • DRM 30 (Digital Radio Mondial) is still in its experimental phase.  It has been demonstrated to work reasonably well on HF.  Several digital data formats are successfully being used on HF; HFDL, ALE, STANAG 5066, PACTOR and others.  DRM 30 has an advantage that H.264 video can also be transmitted.
  • The VOA has been experimenting with images transmitted via MFSK, AKA the “VOA Radiogram.”
  • HF is always susceptible to changing propagation.  However, it can be reliable enough, especially when frequency diversity is employed, to overcome these issues when no other method of communication is available.
  • DRM and MFSK can be decoded using a simple shortwave radio and a computer sound card.  A DRM CODEC is required, but those are readily available for download.
  • Analog shortwave broadcasting using AM is still viable.  AM has the advantage of being extremely simple to receive and demodulate.  Simple receiver kits can be built and run on 9 volt a battery.
  • While the Soviet Union had an extensive jamming network, those sites have long since been non-functional.  Most countries have discontinued the practice of jamming with the exception of China, North Korea, Cuba and perhaps some countries in the middle east (the usual suspects).

Sample of DRM reception via shortwave:

If the internet is censored or somehow becomes unavailable in that part of the world,  shortwave may be the only method to convey an alternate point of view.

Hopefully, things will settle down and return to at least a civil discourse.  However, it never hurts to have a plan.

Axiom


A pessimist sees the glass as half empty. An optimist sees the glass as half full. The engineer sees the glass as twice the size it needs to be.

Congress shall make no law respecting an establishment of religion, or prohibiting the free exercise thereof; or abridging the freedom of speech, or of the press; or the right of the people peaceably to assemble, and to petition the Government for a redress of grievances.
~1st amendment to the United States Constitution

Any society that would give up a little liberty to gain a little security will deserve neither and lose both.
~Benjamin Franklin

The individual has always had to struggle to keep from being overwhelmed by the tribe. To be your own man is hard business. If you try it, you will be lonely often, and sometimes frightened. But no price is too high to pay for the privilege of owning yourself.
~Rudyard Kipling

Everyone has the right to freedom of opinion and expression; this right includes the freedom to hold opinions without interference and to seek, receive and impart information and ideas through any media and regardless of frontiers
~Universal Declaration Of Human Rights, Article 19

...radio was discovered, and not invented, and that these frequencies and principles were always in existence long before man was aware of them. Therefore, no one owns them. They are there as free as sunlight, which is a higher frequency form of the same energy.
~Alan Weiner

Free counters!