October 2016
M T W T F S S
« Aug   Nov »
 12
3456789
10111213141516
17181920212223
24252627282930
31  

Archives

Categories

The Energy Onix Pulsar transmitter

Engineering Radio: The Oh Dear God Edition.

I have been tasked with fixing one of these glorious contraptions. Aside from the usual Energy Onix quirks; design changes not reflected in the schematic diagram and a company that no longer exists, it seems to fairly simply machine. Unfortunately, it has spent its life in less than ideal operating conditions.

Energy Onix Pulsar 1000 in the wild. Excuse the potato quality photo

Energy Onix Pulsar 1000 in the wild. Excuse the potato quality photo

Upon arrival, it was dead in the water.  Found copious mouse droppings, dirt and other detritus within and without of the transmitter.  Repaired the broken start/stop switches, fixed the RF drive detector, replaced the power supply capacitors and now at least the unit runs.  The problem now is the power control is unstable.  The unit comes up at full power when it first switched on, then it drops back to 40 watts, then after it warms up more goes to about 400 watts and the audio sounds distorted.  This all points towards some type of thermal issue with one of the power control op amps or other composite device.

After studying the not always accurate schematic diagrams, the source of the problem seems to be carrier level control circuit.  This is based around a Fairchild RC4200AN (U10 on the Audio/PDM driver board) which is an analog multiplier chip.   That chip sets the level of the PDM audio output which is fed into the PDM integrator circuit.  Of course, that chip is no longer manufactured.  I can order one from China on eBay and perhaps that will work out okay.  This all brings to mind the life cycle of solid state components.  One problem with the new technology; most solid state components have a short production life, especially things like multiplier chips.  Transmitters are generally expected to last 15-20 years in primary service.  Thus, transmitter manufactures need to use chips that will not become obsolete (good luck with that), or purchase and maintain a large stock of spare parts.

In the mean time, the chip is on its way from China.  Truth be told, this fellow would be better off with a new transmitter.

Axiom


A pessimist sees the glass as half empty. An optimist sees the glass as half full. The engineer sees the glass as twice the size it needs to be.

Congress shall make no law respecting an establishment of religion, or prohibiting the free exercise thereof; or abridging the freedom of speech, or of the press; or the right of the people peaceably to assemble, and to petition the Government for a redress of grievances.
~1st amendment to the United States Constitution

Any society that would give up a little liberty to gain a little security will deserve neither and lose both.
~Benjamin Franklin

The individual has always had to struggle to keep from being overwhelmed by the tribe. To be your own man is hard business. If you try it, you will be lonely often, and sometimes frightened. But no price is too high to pay for the privilege of owning yourself.
~Rudyard Kipling

Everyone has the right to freedom of opinion and expression; this right includes the freedom to hold opinions without interference and to seek, receive and impart information and ideas through any media and regardless of frontiers
~Universal Declaration Of Human Rights, Article 19

...radio was discovered, and not invented, and that these frequencies and principles were always in existence long before man was aware of them. Therefore, no one owns them. They are there as free as sunlight, which is a higher frequency form of the same energy.
~Alan Weiner

Free counters!