January 2011
« Dec   Feb »



The mechanical tower light flasher

This is a Hughey Phillips mechanical tower light flasher that has been in service since 1960. Basically it is a motor connected to a cam that rocks a mercury relay back and forth. These were standard technology for tower lights from the 1930’s through about 1970 or a little later.  They were very reliable, we still have some with a “pancake motor” in use on some of our towers.  They were very robust and immune to lightning damage, RF interference and other problems.  The only maintenance that I can think of is lubricating the motor bearings.  Eventually, however, they do wear out.  Cold weather seems to take its toll, often causing the motor to stop.

Hughey and Phillips mechanical tower light flasher

Hughey and Phillips mechanical tower light flashe

This particular unit is mounted inside the tuning house for the far tower (north tower) at the WGHQ antenna array.  It has finally reached the end of it’s existence; the motor bearings are shot and it has gotten stuck in both the on and off position this year causing the FAA to be notified of the malfunction.

WGHQ 920 Khz Kingston, NY antenna array

WGHQ 920 Khz Kingston, NY antenna array

Today, I am replacing it with a solid state flasher (SSAC B-KON FS155-30RF).  Solid state flasher units have been known to malfunction in high RF fields, such as AM towers.  To cure that, the manufacture has built in 0.01 uf bypass capacitors, hence the “RF” suffix.  Older units did not have the built in bypass caps, so external 0.1 uf bypass capacitors were normally installed on units mounted to AM towers.  While I was working on this, I turned the transmitter down to 500 watts, no need getting any RF burns.

Naturally, this has to happen after there is two feet of snow on the ground.  Also, it should be noted that this is the furthest tower away from the transmitter building.  Now where did I put those snow shoes?  Never mind, it has been very cold and the ground is frozen solid, I’ll take the truck…  This is good because I will have all the tools, drills, nuts and bolts without having to walk back and forth several times in the snow.

Hughey Phillips mechanical beacon flasher

Hughey Phillips mechanical beacon flasher

I removed the motor and mercury filled relay.  I’ll have to figure out how to dispose of the relay.  I then drilled a mounting hole through the base of the old flasher housing and bolted the solid state relay to it.  This is required because the solid state relay needs a pretty good heat sink.

SSAC B-KON tower light flasher

SSAC B-KON tower light flasher

Turn everything back on and:  Ta-da! All works normally, tower beacon is flashing away up there.  Time to leave.

Truck stuck in swamp

Truck stuck in swamp

Pull forward about 2 feet to turn around and CRUNCH!  The truck goes through the ice of a hidden stream.  Any attempt to move only makes it worse:

Truck rear burried to axle

Truck rear burried to axle

Put in a phone call to the one guy I know that can get me out.  About an hour later he shows up with chains, a shovel and a come-a-long.  We attach the come-a-long to the fence support post and pull the truck out backwards 1/2 inch at a time.  It took us about an hour and a half to get it all the way out so I could drive it back across the field.  I’d have taken some pictures, but my guy; he was a little grumpy.

I won’t do that again.

Still, I did the job I came to do, so it was a good day after all.


A pessimist sees the glass as half empty. An optimist sees the glass as half full. The engineer sees the glass as twice the size it needs to be.

Congress shall make no law respecting an establishment of religion, or prohibiting the free exercise thereof; or abridging the freedom of speech, or of the press; or the right of the people peaceably to assemble, and to petition the Government for a redress of grievances.
~1st amendment to the United States Constitution

Any society that would give up a little liberty to gain a little security will deserve neither and lose both.
~Benjamin Franklin

The individual has always had to struggle to keep from being overwhelmed by the tribe. To be your own man is hard business. If you try it, you will be lonely often, and sometimes frightened. But no price is too high to pay for the privilege of owning yourself.
~Rudyard Kipling

Everyone has the right to freedom of opinion and expression; this right includes the freedom to hold opinions without interference and to seek, receive and impart information and ideas through any media and regardless of frontiers
~Universal Declaration Of Human Rights, Article 19

...radio was discovered, and not invented, and that these frequencies and principles were always in existence long before man was aware of them. Therefore, no one owns them. They are there as free as sunlight, which is a higher frequency form of the same energy.
~Alan Weiner

Free counters!